Product ID:TYPE I WALKWAY DARK GULL GRAY
MSDS Date:07/26/1990
FSC:8010
NIIN:00-641-0428
MSDS Number: BPMSZ

AKRON PAINT AND VARNISH INC

1390 FIRESTONE PKY
AKRON, OH 44301-1624
US

Emergency Phone: 330-773-8911

Info Phone: 330-773-8911

Preparer: ED APSEGA

Cage: 70228

AKRON PAINT AND VARNISH INC

AKRON, OH 44301-1624 US

Telephone: 216-773-8911

Cage: 70228

ALIPHATIC PETR.DISTILLATES (VAPOR PRESSURE 26 MM HG) <8%

CAS: 64742-89-8

Fraction By Weight: 20-50%

OSHA PEL 300 PPM/14 STEL

ACGIH TLV: 300 PPM

METHYL PROPYL KETONE (VAPOR PRESSURE 28 MM HG)

CAS: 107-87-9

RTECS: SA7875000

Fraction By Weight: 1-5%

OSHA PEL 710 MG/M3

ACGIH TLV: 875 STEL

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE REDNESS, IRRITATION,
SWELLING AND BLURRED VISION. SKIN: PROLONGED OR REPEATED CONTACT
CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS. INHALATION:
EXCESSIVE INHALATION OF VAPORS AND/OR SPRAY MIST CAN CAUSE
RESPIRATORYIRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA,
HEADACHE, UNCONSCIOUSNESS AND+
Effects of Overexposure:+EVEN ASPHYXIATION. INGESTION: CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND DIARRHEA;
ASPIRATION OF MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL
PNEUMONITIS WHICH CAN BE FATAL.

First Aid:EYES: FLUSH W/LG AMTS OF WATER, LIFTING LIDS FOR 15 MIN. GET
PROMPT MED AID. SKIN: WASH THOROUGHLY W/SOAP & WATER, RMV CONTAM
CLOTH IMMED; LAUNDER BEFORE REUSE. CONSULT A DR IF IRRIT PERSISTS.
INGEST: DO NOT INDUCE VOMIT. KEEP WARM/QUIET-GET MED ATTN. ASPIR
OF MATL INTO LUNGS DUE TO VOMITING CAN CAUSE CHEM PNEUMONITIS
(FATAL). DRINK 1 TO 2 GLASSES OF WTR TO DILUTE. INHAL: MOVE TO
FRESH AIR. IF##

Flash Point Method:TCC
Flash Point:46.0F,7.8C
Lower Limits:1.%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG. USE
WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE
PRESSURE MODE. WEAR PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS HEAVIER THAN AIR-MAY TRAVEL ALONG
GROUND TO IGNIT SOURCE SOME DISTANCE FROM MATL HNDLNG PT. IGNIT
SRCS INCLUDE PILOT LIGHTS/SMOKING/HEATERS/ELECT MOTORS*

Spill Release Procedures:SM: ABSORB LIQ W/RAGS/FLOOR-OTHER
ABSORB/VERMICULITE & TRANS TO HOOD. LG: ELIM ALL IGNIT SRCS. DIKE
AREA OF SPILL TO PREVENT SPREADING. VENT AREA (INDOORS)-PUMP LIQ
INTO SALVAGE TANK-REMAIN LIQ MAY BE TAKEN UP W/SAND,FLOOR-OTHER
ABSORB & SHOVEL INTO$
Neutralizing Agent:N/K ##BREATHING DIFF-ADMIN OXYGEN, IF STOPPED-GIVE
ARTIF RESP. KEEP WARM/###

Handling and Storage Precautions:DONT DROP CNTNRS. AVOID
HEAT/SPARKS/OPEN FLAME/BREATH SANDING DUST. STORE LG QTY IN BLDGS
DESIGNED TO COMPLY W/OSHA 1910.106. NEVER USE PRESS TO EMPTY
Other Precautions:INFO ACCUMULATED HEREIN IS BELIEVED TO BE ACCURATE
BUT IS NOT WARRANTED TO BE WHETHER ORIGINATING W/THE COMPANY OR
NOT. RECIPIENTS ARE ADVISED TO CONFIRM PRIOR OF NEED THAT INFO IS
CURRENT, APPLICABLE & SUITABLE TO THEIR CIRCUMSTANCES.

Respiratory Protection:IN OUTDOOR OR OPEN AREAS WITH UNRESTRICTED
VENTILATION APPROVED CHEMICAL/MECHANICAL FILTERS DESIGNED TO REMOVE
A COMBINATION OF PARTICULATES AND VAPOR. IN CONFINED AREAS,
APPROVED AIR LINE TYPE RESPIR ATORS OR HOODS.
Ventilation:SUFFIC VENT IN VOL/PATRN TO KEEP AIR CONTAM CONC BELOW
CURRENT APPLICABLE OSHA PERMISS EXPOS LIMIT/ACGIH TLV LIMIT, &
Protective Gloves:NITRILE RUBBER
Eye Protection:CHEM SPLASH GOGGLES/OTHER SAFETY GLASSES
Other Protective Equipment:NORMAL PROTECTIVE CLOTHING. WASH
CONTAMINATED CLOTHING BEFORE REUSE. VOLATILES BELOW LWR EXPLOS
LIMIT. HEAVY SOLVENT
Work Hygienic Practices:N/K VAPORS SHOULD BE RMVD FROM THE LWR LEVELS
OF AREA & IGNIT SRCS (NON-EXPLOS PROOF EQUIP) SHOULD BE ELIM IF
FLAMM
Supplemental Safety and Health
MIX PRESENT. RMV DECOMP PROD FORMED DURING WELD/FLAME CUT OF COATED
SURFACES. FOR BAKING FINISHES-VENT VAPORS EMITTED ON HEATING. HOT
ORGANIC CHEM VAPORS/MISTS ARE SUSCEPTIBLE TO SPONTANEOUS COMBUS
TION WHEN MIXED W/AIR. IGNIT MAY OCCUR AT TEMP BELOW THOSE
PUBLISHED AS AUTOIGNITION OR IGNITION TEMPERATURES.

HCC:F2
Boiling Pt:B.P. Text:217-270F
Vapor Density:> THAN AIR
Spec Gravity:1.15
Evaporation Rate & Reference:0.99 X N-BUTYL ACETATE
Appearance and Odor:DARK GULL GRAY LIQUID
Percent Volatiles by Volume:58.9

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZERS (NITRIC ACID). #CNTNRS. RESIDUAL
SOLVENT VAPOR IN EMPTY CNTNR MAY EXPLODE. APPLICATN**
Stability Condition to Avoid:KEEP AWAY FROM HEAT & OPEN FLAME. *SPARKS
FROM ELECT SWITCHES/STATIC DSCHRG. CAUTION: NEVER USE CUTTING TORCH
ON EMPTY#
Hazardous Decomposition Products:MAY FORM CO, CO2, VARIOUS
HYDROCARBONS, ETC. **TO HOT SURFACES REQ SPECIAL PRECAUTIONS.
DURING EMERG CONDITIONS,***

Waste Disposal Methods:DISPOSE OF IN ACCORD W/FEDERAL, STATE & LOCAL
REGULATIONS. ###QUIET & GET MED ATTN. CONSULT A PHYSICIAN.
$CONTAINERS-PREVENT RUN-OFF TO SEWERS AND BODIES OF WATER. NOTIFY
PROPER AUTHORITIES AS R EQUIRED BY LOCAL, STATE AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.